What should coking workers pay attention to?

Safety operation procedures of coke oven

1, coke pusher, coke stopper, coke quenching car and coal loader must send out audio signals before driving; No getting on or off while driving; Except walking, each unit should be able to operate automatically according to the program; The driver's cab should be paved with heat insulation board. 2, coke pusher, coke stop car and coke quenching car, should have calls, signal contact and interlock. 3, coke pusher, coal car and coke quenching car, should be set up when the compressed air pressure overrun the automatic stop of the air compressor interlock device. In the driver's cab, a wind pressure gauge and a wind pressure limiting acousto-optic signal should be set. 4, coke pusher, flat coal car, coal door, tamping car, coal door and coal drop sleeve of coke stop car shall be equipped with parking interlocking device. 5, coke pusher and coke stop car should be equipped with mechanized cleaning furnace door, furnace rack and cleaning furnace end coke equipment. 6, coke pusher should be set up machine side workers lounge. 7. A tongue plate that can cover the gap between consoles on the side of the machine should be set along the length of the coke pusher, and there should be no obvious steps between the tongue plate and the console. 8. The coke pusher should be equipped with travel limit signal, limit switch and tail movable teeth or mechanical gears. The tilt angle of the tail tilting coke pusher should be greater than 90 and less than 96. 9, leveling rod and coke pusher should be equipped with manual device, and should have automatic power interlock when manual. 10, when the coke pusher is interrupted for some reason, the drivers of the coke quenching car and the coke blocking car shall not leave the coke receiving position without the permission of the captain of the coke pusher. 1 1. When the movable wall and the front door of the coal bunker are not closed, tamping with a tamping machine is prohibited. 12, the coke stop car of coke oven and the coke side column shall be provided with safety stops and guide rails respectively. 13. The coke barrier shall be freely detachable from the car body of the coke barrier and located on the side of the coke barrier near the coke quenching tower. 14, the cab of the quenching car should be equipped with a signal device indicating that the door is locked. 15, anti-freezing measures should be taken for coke quenching car tracks in cold areas. 16, the distance between the coal loader and the buildings on both sides of the top machine and coke shall not be less than 800 mm. 17, and the exchange transmission device must act in the order of closing the gas first, then exchanging air and waste gas, and finally opening the gas. The switch shall be equipped with a manual device.